2010_C30_S40_(04-)_V50_C70(06-)_wiring_diagram.pdf
(
11113 KB
)
Pobierz
VOLVO C30, S40 (04-), V50 & C70 (06-)
WIRING DIAGRAM
2010
TP 39150201
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminal
Data link connector in the passenger compartment.
Changes introduced up to and including December 2008
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from Technical Information Shop (TIS) at
w ww.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.
© Volvo Car Corporation
Table of Contents 1:3
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain) ......................................................... 2
Abbreviations ................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution 1:2................................................ 9
Group 23 Fuel system
Engine management system, 4-Cyl. 1.6l 1:2 ............... 52
Engine management system, 4-Cyl. 1.8l & 2.0l 1:2 ..... 54
Engine management system, 5-Cyl. 1:2 ...................... 56
Engine management system, 5-Cyl. Turbo 1:2............ 58
Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 60
Engine management system Diesel, 4-Cyl. 2.0l 1:2 .... 62
Engine management system Diesel, 4-Cyl. 2.0l
MPS6 1:2 ..................................................................... 64
Engine management system Diesel, 5-Cyl. 2.4l 1:3 .... 66
Emission control 4-Cyl. 1.6l ......................................... 69
Emission control, 4-Cyl. 1.8l & 2.0l .............................. 70
Emission control 5-Cyl. ................................................ 71
Emission control 5-Cyl. Turbo...................................... 72
Fuses
Engine compartment distribution box F1-F7................. 11
Distribution box in engine compartment F8-F16........... 12
Distribution box in engine compartment F17-F25......... 13
Distribution box in engine compartment F26-F32......... 14
Distribution box in engine compartment F33-F34......... 15
Engine compartment distribution box F35-FH1 ............ 16
Main fuse box battery ................................................... 17
Fuse holder midi ........................................................... 18
Central Electronic Module (CEM) F43-F48................... 19
Central Electronic Module (CEM) F49-F61................... 20
Central Electronic Module (CEM) F62-F69................... 21
Central Electronic Module (CEM) F73-F85................... 22
Central Electronic Module (CEM) F86 .......................... 23
Battery PF1-PF2 ........................................................... 24
Group 26 Cooling system
Cooling fan................................................................... 73
Group 27 Engine controls
Cruise control 4-Cyl. ..................................................... 74
Cruise control 5-Cyl. ..................................................... 75
Start/stop function ......................................................... 76
Relays
Ignition switch and relays............................................. 25
Distribution box in engine compartment R1-R14 ......... 26
Engine compartment.................................................... 27
Central electronic module (CEM) R15-R18 ................. 28
Central electronic module (CEM) R1-R11B................. 29
Other relays ................................................................. 30
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. ..................................................... 77
Power supply 5-Cyl. ..................................................... 78
Group 33 Starting system
Starting system 4-Cyl................................................... 79
Starting system 5-Cyl................................................... 80
Ground connections
Overview...................................................................... 31
31/3 - 31/10 cont.......................................................... 32
31/10 - 31/11 ............................................................... 33
31/12 - 31/66 cont........................................................ 34
31/66 - 31/80 ............................................................... 35
31/83 - 31/102 ............................................................. 36
31/107 - 31/114 ........................................................... 37
31/115 - 31/160 ........................................................... 38
Ground connections in chassis.................................... 39
Group 35 Lighting
High and low beam ...................................................... 81
Active headlights, (Dual Xenon) S40/V50.................... 82
High and low beam, (Dual Xenon) C30/C70................ 83
Running/Parking lights, Tail lights S40/V50 ................. 84
Running/Parking lights, Tail lights (Dual Xenon)
S40/V50 ....................................................................... 85
Running/Parking lights, Tail lights C30/C70................. 86
Running/Parking lights, Tail lights (Dual Xenon)
C30/C70....................................................................... 87
Brake lights S40/V50 ................................................... 88
Brake lights C30/C70 ................................................... 89
Reversing lights S40/V50............................................. 90
Reversing lights C30/C70 ............................................ 91
Fog lights S40/V50 ...................................................... 92
Fog lights C30/C70 ...................................................... 93
Fog lights LHD Japan S40/V50.................................... 94
Fog lights LHD Japan C30/C70 ................................... 95
Follow-me-home lighting.............................................. 96
Interior lighting C30/S40/V50 1:2 ................................. 97
Interior lighting C70 1:2................................................ 99
Instrument and control illumination ............................ 101
Auxiliary lights ............................................................ 102
Control modules
Overview locations....................................................... 40
Overview designations................................................. 41
Central electronic module (CEM) 1:2........................... 42
Data communication, Low speed CAN 1:2 .................. 44
Data communication, High speed CAN ....................... 46
Data communication MOST......................................... 47
Data communication LIN 1:2 ....................................... 48
Ignition switch (SCU) ................................................... 50
Accessory electronic module (AEM)............................ 51
TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010
3
Table of Contents 2:3
Group 36 Additional electrical equipment
Direction indicators and hazard warning flashers
S40/V50 ..................................................................... 103
Direction indicators and hazard warning flashers
(Dual Xenon) S40/V50............................................... 104
Direction indicators and hazard warning flashers
C30/C70..................................................................... 105
Direction indicators and hazard warning flashers
(Dual Xenon) C30/C70 .............................................. 106
Wiper/washer windshield ........................................... 107
Washer headlights ..................................................... 108
Wiper/washer rear window C30/V50 ......................... 109
Rain sensor................................................................ 110
Keyless vehicle C30/S40/V50 1:2.............................. 111
Keyless vehicle C70 1:2 ............................................ 113
Parking assistance..................................................... 115
Immobilizer/Steering column lock module (SCL)....... 116
Horn ...................................................................... 117
Anti-theft alarm C30................................................... 118
Anti-theft alarm S40/V50............................................ 119
Anti-theft alarm C70................................................... 120
Alcolock ..................................................................... 121
Accessory Electronic Module (AEM) C30.................. 122
Accessory Electronic Module (AEM),
S40/V50/C70 ............................................................ 123
Cellular phone 1:2...................................................... 143
Multimedia & Traffic information ................................ 145
Satellite radio ............................................................. 146
Subwoofer.................................................................. 147
Portable navigation system........................................ 148
Bluetooth.................................................................... 149
Bluetooth Handsfree, internal amplifier...................... 150
Bluetooth Handsfree, external amplifier..................... 151
Bluetooth Handsfree & AUU, internal amplifier.......... 152
Bluetooth Handsfree & AUU, external amplifier......... 153
Bluetooth Handsfree with AEM, internal amplifier,
LHD ...................................................................... 154
Bluetooth Handsfree with AEM, internal amplifier,
RHD ...................................................................... 155
Bluetooth Handsfree with AEM, external amplifier,
LHD ...................................................................... 156
Bluetooth Handsfree with AEM, external amplifier,
RHD
...................................................................... 157
Group 43 Transmission
Automatic transmission AW55-51.............................. 158
Transmission M66...................................................... 159
Automatic transmission MPS6 ................................... 160
Differential Electronic Module (DEM) S40/V50 .......... 161
Group 59 Brake system
Brake control system & STC...................................... 162
Brake control system & DSTC ................................... 163
Group 37 Wiring and fuses
12V outlet C30/S40/V50 ............................................ 124
12V outlet, C70 .......................................................... 125
Diagnostics system.................................................... 126
Cable harness towbar/tow hitch 4-pin S40/V50......... 127
Cable harness towbar/tow hitch 4-pin C30/C70 ........ 128
Cable harness towbar/tow hitch 7-pin S40/V50......... 129
Cable harness towbar/tow hitch 7-pin C30/C70 ........ 130
Cable harness towbar/tow hitch 13-pin
S40/V50/C70 ............................................................. 131
Cable harness towbar/tow hitch 13-pin C30 .............. 132
USB unit (AUU).......................................................... 133
Group 64 Steering
Speed dependent power steering .............................. 164
Group 83 Doors and openings
Central locking front doors C30/S40/V50................... 165
Central locking rear doors S40/V50 ........................... 166
Central locking C70.................................................... 167
Central locking trunk lid/tailgate C30 ......................... 168
Central locking trunk lid/tailgate S40/V50 .................. 169
Central locking trunk lid/tailgate C70 ......................... 170
Central locking storage compartment C70................. 171
Child safety lock S40/V50 .......................................... 172
Central locking fuel filler flap ...................................... 173
Signal receiver central locking C30/S40/V50............. 174
Signal receiver central locking C70............................ 175
Power windows front doors C30/S40/V50 ................. 176
Power windows C70 .................................................. 177
Power windows rear doors S40/V50.......................... 178
Power sunroof C30/S40/V50 ..................................... 179
Power roof C70 .......................................................... 180
Group 38 Instruments
Driver information module.......................................... 134
Seat belt reminder C30/S40/V50 ............................... 135
Seat belt reminder C70.............................................. 136
Group 39 Other
Audio C30/S40/V50 ................................................... 137
Audio C70 .................................................................. 138
Audio High Performance/Premium Sound
C30/S40/V50 1:2 ....................................................... 139
Audio High Performance/Premium Sound C70 1:2 ... 141
TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010
4
Table of Contents
3:3
Group 84 Exterior decorative elements, etc.
Power door mirrors C30/S40/V50.............................. 181
Power door mirrors C70............................................. 182
Heated door mirrors................................................... 183
Rear window defroster............................................... 184
Blind spot information system.................................... 185
Power passenger seat RHD S40/V50........................ 195
Heated seats.............................................................. 196
Group 87 Climate control system
Climate control system, 4-Cyl. Gasoline 1:2 .............. 197
Climate control system, Diesel 1.6l & 2.0l 1:2............ 199
Climate control system, 5-Cyl. 1:2 ............................. 201
Climate control system PTC-elements....................... 203
Parking heater, auxiliary heater ................................. 204
Relay, electric engine heater ..................................... 205
Electric engine heater Flexifuel.................................. 206
Group 85 Interior equipment
Power driver’s seat with memory function LHD
S40/V50 ..................................................................... 186
Power driver’s seat with memory function RHD
S40/V50 ..................................................................... 187
Power driver’s seat with memory function LHD
C30/C70..................................................................... 188
Power driver’s seat with memory function RHD
C30/C70..................................................................... 189
Power passenger seat with memory function LHD
C30/C70..................................................................... 190
Power passenger seat with memory function RHD
C30/C70..................................................................... 191
Power driver’s seat LHD S40/V50 ............................. 192
Power driver’s seat RHD S40/V50............................. 193
Power passenger seat LHD S40/V50 ........................ 194
Group 88 Internal equipment
Supplemental restraint system C30/S40/V50 1:2 ...... 207
Supplemental restraint system C70 1:2 ..................... 209
Remote controlled garage door opening.................... 211
Rear-view mirror with automatic dimming.................. 212
Index 1:2 ....................................................213
List of components 1:6 ............................215
TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010
5
Plik z chomika:
zgielek
Inne pliki z tego folderu:
1994_850_wiring_diagram.pdf
(35362 KB)
1994_940_wiring_diagram.pdf
(26858 KB)
1994_960_wiring_diagram.pdf
(31545 KB)
1995_850_wiring_diagram.pdf
(41605 KB)
1995_940_wiring_diagram.pdf
(51957 KB)
Inne foldery tego chomika:
African Roots
AirBagServiceTool 3.9
AirBagServiceTool 3.9(1)
Desert Blues 3 (Entre_Dunes_Et_Savanes)
Dokumenty
Zgłoś jeśli
naruszono regulamin